Instructions for useInstallation and servicingThema CONDENS F 18 E SBThema CONDENS F 24 EThema CONDENS F 30 ECONDENSING BOILER + INSTANTANIOUS HOT WAT
9Instructions for UsePush “MODE” to modify the operating mode of the boiler. The green LED indicates the selected mode. Central heating Appliance fr
1012 Frost protection12.1 Boiler frost protectionIn case of frost risk, do as follows:Make sure the boiler is supplied with electrical power and gas.
Installation and servicing instructions strictly reserved for qualified gas installers11Installation and servicingIndex1 Comments on the instructions
129 Gas conversion ...329.1 Maximum power setting ...
Installation and servicing instructions strictly reserved for qualified gas installers131 Comments on the instructionsPlease give all of the instructi
142.3 Block diagram 29Legend1 Flue outlet2 Main heat exchanger 3 Burner4 Ignition and control electrode5 Fan6 Gas control valve7 Condensate tr
Installation and servicing instructions strictly reserved for qualified gas installers153 Appliance locationThis appliance is not suitable for outdoor
16The following safety instructions must be imperatively followed during the maintenance and the replacement of spare parts.Stop the appliance (see ch
Installation and servicing instructions strictly reserved for qualified gas installers17must not be taken as overriding statutory requirements.If the a
185.1.3 Water treatmentIn the case of an existing installation, it is Essential that prior to installing the new boiler the system is thoroughly flush
1Instructions for UseInstructions for useIndex1 General points ...22 Documents
Installation and servicing instructions strictly reserved for qualified gas installers19Chose the location of the appliance. See chapter “Appliance loc
20wall205,511623456478910891A1146132121415LegendConnection pack:A Pressure test point2 Heating pipe: angular bush to weld Ø 22 + nut 3/4" (x2
Installation and servicing instructions strictly reserved for qualified gas installers215.7 Connection to the condensate trap5.7.1 Filling of the con
225.8 Flue connectionDifferent flue outlet configurations can be carried out.Consult your supplier for more information about the other possibilities a
Installation and servicing instructions strictly reserved for qualified gas installers23PositionPosition of the flue terminalmmHorizontal fluesAdirectl
245.8.2 Vertical concentric flue Ø 60/100 (C33 type installation) LMaximum flue index: 150 PaThis value is reached with the length of the maximum du
Installation and servicing instructions strictly reserved for qualified gas installers25Open the installer connection side (2) to carry out the electri
265.10 Wiring diagram12346578910111213141516
Installation and servicing instructions strictly reserved for qualified gas installers27Legend1 Ignition module2 Ignition and control electrode3 Hea
286 CommissioningSlide the switch until the “I” symbol appears.The display and operating mode indicator light up: the boiler is ready to run.Open the
21 General pointsThe Thema CONDENS boiler is an appliance that uses condensing technology, which recovers heat present in waste gas.Thanks to this op
Installation and servicing instructions strictly reserved for qualified gas installers29Output/pressure curve ThemaCondens F 24 E70605040302010500 1400
307.2 Access to the boilers technical data (for professional and After Sales Service use only)The access to the boilers technical data allows you to
Installation and servicing instructions strictly reserved for qualified gas installers31COD. 7 heating curve baseChoose a value: 15°C / 16°C / 17°C / 1
328 Draining of the appliance8.1 Heating circuitTurn on the drain cock (1) provided at the system low point.Provide an air intake by opening a radia
Installation and servicing instructions strictly reserved for qualified gas installers339.1.2 Setting from G31 to G20Turn the screw (3) 2 full turns a
3410 Fault findingYou will find the list of some fault codes in the operating instructions.The faults described in this chapter should be carried out b
Installation and servicing instructions strictly reserved for qualified gas installers35
3611 Control / CommissioningOnce the appliance is installed, check whether it runs:Start the appliance according to the indications of the operating
Installation and servicing instructions strictly reserved for qualified gas installers3714.2 Removable plate / Silencer3214Legend1 Upper silencer2 U
3814.4 Hydraulic blockTOP12827262524232221201918171614152435678910111213
3Instructions for UseDo not change: - The appliance, - The appliance environment, - Water, air, gas and electric supply, - Flue system. Never carry
Installation and servicing instructions strictly reserved for qualified gas installers39Legend1 Automatic air vent 2 Pump retaining screw 3 Pump 4
4014.5 Combustion block123456879111413121510Legend1 Burner unit retaining screws2 Gasket 3 Burner4 Burner unit5 Burner unit retaining nuts6 Ign
Installation and servicing instructions strictly reserved for qualified gas installers4114.5.1 Dismantling the burner unitRemove the silencer (see ch
4215 Remplacement of partsWarning!Before starting the remplacement of parts, read carefully the chapter “Safety instructions”.•Ensure boiler is draine
Installation and servicing instructions strictly reserved for qualified gas installers43Legend1 Automatic air vent 2 Pump retaining screw 3 Pump 4
44Remove the 3-way valve (24).Fit the new 3-way valve by repeating the operations in reverse.15.1.7 Discharge valveRelease the discharge outlet.•••R
Installation and servicing instructions strictly reserved for qualified gas installers45Legend1 Heat exchanger retaining screw2 Heat exchanger retain
4615.2.5 Fan Remove the gas valve (15) (see previous paragraph).Remove the fan connector (18).Loosen the 4 screws (8) located on the burner unit (7)
Installation and servicing instructions strictly reserved for qualified gas installers47After fitting a new expansion vessel, fill and purge the applianc
4815.5 Control panel15.5.1 Main PCBA19A876A234A5BLegend1 Hydraulic harness connector2 Combustion harness connector3 Main PCB harness connector4
4This guarantee is in addition to your statutory and other legal rights, whichwill not be excluded or diminished by the return of the guarantee regist
Installation and servicing instructions strictly reserved for qualified gas installers49
5016 Technical dataBoiler type C13, C33, C53Description Unit F 18 E SB F 24 E F 30 EGas category ll2H3PHeatingHeating output at 80°C/60°C (P)kW 8.4 -
Installation and servicing instructions strictly reserved for qualified gas installers51Description Unit F 18 E SB F 24 E F 30 ECombustionFresh air flo
0020009247-02 06/05Saunier Duval, Nottingham RoadBelper,DerbyshireDE56 1JTTel. 00 44 (0)1773 525914Fax. 00 44 (0)1773 828070www.saunier-duval.co.uk
5Instructions for Use
68 Appliance use: Thema Condens8.1 Control panel 2456713progtimeLegend1 Operating mode indicators2 LCD display3 Operating mode selection4 DH
7Instructions for UsePush “MODE” to modify the operating mode of the boiler. The green LED indicates the selected mode. Domestic hot water + Timed c
89 Appliance use: Thema Condens SB9.1 Control panel 435261Legend1 Operating mode indicators2 LCD display 3 Operating mode selection4 Heating
Commentaires sur ces manuels